Member record · ID 40510
GreenOnion84
16 posts recovered 1 thread started First seen 13 Jun 2019 Last seen 6 Jul 2019
Threads started
1 in the archiveRecent posts
All 16- 1995 - Stops charging when warm 11 hours ago, Grum There's just no way your R/R should be getting that hot. Assuming your stator is now OK and you've tried another R/R then the only thing that can cause excessive heat is the load on the system,…
- 1995 - Stops charging when warm mello dude, 7/3/2019 at 7:03 AM Your symptoms still act like a bad stator leg while hot. Plz do the stator test while hot and gimme data. I don't care what Rick's says.. ...No on the bike numbers... no help. You…
- 1995 - Stops charging when warm 51 minutes ago, COS_VFR When you mention the frame getting hot, are you talking about the subframe where the Regulator is mounted? If it is too hot to touch, it sounds like the regulator is sinking too much current and…
- 1995 - Stops charging when warm Well. The stator is putting out the right numbers. Installed it today and put the new Ricks regulator on. Took it for a ride. Tested it after the ride again to make sure it was still putting out good numbers. Stator is…
- VFR Visits the White Mountains I'm jealous. Beautiful landscapes, but that is my dream bike. I've wanted one since they first came out. I'll trade you my 95 and a case of brewski's. ;P Just curious though. Do you always put it on the center stand or…
- 1995 - Stops charging when warm 23 hours ago, Grum That sounds promising. A pinched wire with the screws on that cover plate has caused issues with other people. It could well be a situation when heated it shorts to frame. Good luck with the repaired…
- 1995 - Stops charging when warm Grum, 6/15/2019 at 9:26 PM Yeah me to, that's why I mentioned three times for the OP to check the main fuse and starter relay area. He claims all is good there to! I took the main fuse out and even replaced it even…
- 1995 - Stops charging when warm Okay, here's an update. I purchased the stator from Rick's Motorsport. I suspected the stator might be defective because I didn't think the AC volts were sitting where they should , so I sent it in for testing. Rick's…
- 1995 - Stops charging when warm 5 hours ago, Grum Assume you mean 45v AC (not Amps!) most stators at 5000rpm would normally generate an AC voltage of greater than 50v AC. 45v AC seems low. Wonder if you have a load issue that is dropping your charge…
- 1995 - Stops charging when warm 1 hour ago, Grum Warm up the bike to the fault point, stop the engine and unplug the stator connector run the engine and confirm the AC voltage output is correct or not. Or perhaps just back probe the conector and see…
- 1995 - Stops charging when warm Checked it all again. All voltage readings came out fine. Once again as soon as it got warm the voltages dropped like a rock and it stopped charging.
- 1995 - Stops charging when warm 56 minutes ago, COS_VFR The wiring harness has a ground point on the right side of the frame not too far from the stator plug. The ground from the battery is connected on the left side of the bike near the front of the…
- 1995 - Stops charging when warm Any idea where the grounds connect to the frame? If they were corroded, that would affect it too right? When I search for it I can't find the locations of the actual grounds on the frame.
- 1995 - Stops charging when warm 54 minutes ago, Grum No need to be doing bypass. You can't bypass the starter relay all together! You wouldn't be able to start your bike! You don't have any starting issues anyway! Unplug the R/R connector and just…
- 1995 - Stops charging when warm 31 minutes ago, Grum Have a very close inspection of the 30a main fuse within your starter relay for any sign of heat stress, it can suffer from hi resistance contacts. Make sure the R/R ground measures rock solid back…
- 1995 - Stops charging when warm Okay, so here goes. I have charging issues when the bike is warmed up. I replaced the stator as well as the R/R. I also replaced the connector going into the R/R due to one burnt connector. Amps coming out of the stator…
Member profiles were not captured; this page is assembled from the posts that were. Post counts reflect what the archive recovered, not the forum's own totals.